Explorer Talk banner
1 - 3 of 3 Posts

·
Registered
Joined
·
3 Posts
Discussion Starter · #1 ·
I replaced the DPFE on my 96 4.0 and the instructions said that it may set a trouble code. (Both genuine Ford and Standard part) Phoned dealer service to see if they can reset my computer to work with the new unit but they had no idea what I was talking about. Does anyone know what to do? I am in California with smog checks and there can't be any codes to pass smog test.
 

·
Registered
Joined
·
3 Posts
Discussion Starter · #3 ·
Thank you but that isn't what I meant. The new DPFE keeps sending a fault, but the info sheet accompanying the unit says the dealer can re-program PCM. The dealers in the area charge $235 an hour and up.
Just trying to save some bucks, The first dealer I called didn't know what I was talking about and said "That's an old truck."
 

·
Registered
Joined
·
3 Posts
Discussion Starter · #6 ·
First, thanks for the answers.
From a Standard Brands part, the Ford part pretty much said the same if I recall correctly:
". . . Also, be aware that the static or KOEO (key-on, engine-off) voltage reading was 0.55 volts for the aluminum body units, whereas the plastic body units are 1.0 volt. Ford has expanded the specification for this sensor to accommodate this supersession. The new specification is: 0.2 to 1.3 volts. These new voltage ranges will not set the Check Engine Light or cause performance concerns. However, they may set a trouble code when performing a KOEO test due to the old tolerance range set in the PCM. This is considered normal and should be ignored. Ford does not recommend re-flashing the PCM to eliminate this code, and it will only appear in the KOEO mode. This is not an OBD II code."
I get a 301 code but I haven't done further testing and re-testing.
As to dealerships, I know they have changed much over the years and the ones around here (Northern California) are mostly big businesses. I've known a couple of dealers and two service managers that were former mechanics I looked at the business card of the intake person where my wife took her Edge and the title is: "Lincoln Concierge" It was very different when I was young.

I'll work out my problem and if the answer may help someone, I'll post it here
 
1 - 3 of 3 Posts
Top